Jump to content


jaguar s type catalytic converter


kagawa
 Share

Recommended Posts

Hello to everybody

I took my Jaguar s  type  3 litre /2002  today for its m.o.t  and sadly it  failed on the catalytic converters,is there a cross reference for this item from another car  or where  can I buy two, eBay is a option

 regards to all liam 

Link to comment
Share on other sites


 thank you  for  help and reply . it failed on high CO  the  pass  mark for CO was 32  it came in at  62, all  the others were fine, the HC 31 pass 200, Lambda was 1012 pass 970/1030 ,the natural idle test pass  630/830 ,the tester suggested cataclean  and take it for a drive and keep the revs over 4500 , which I did  and returned  for retesting, sadly  not enough of a  affect on the CO  it lowered from 62  to 50 ,so the  conclusion  was failed  or blocked  cat. I put a fault code reader my jag and obtained the following codes   P0420 Catalyst system efficiency below threshold (bank 1) P0430 Catalyst system efficiency below threshold (bank 2) ,it runs lovely its hard to believe it got a fault , but it is all new state of the art mot diagnostics there

regards to all liam

Link to comment
Share on other sites

hi

looking on eBay cats for your car look at about £80 each

dont know if you will get away with changing 1 or the pair

if your in good knick and your thinking of keeping it £160 for a pair of cats is not badly priced compared to a genuine set

cheers

Joe

Link to comment
Share on other sites


  • 2 weeks later...

hello to all

i have put both cats in  my Jaguar now and I have to say, it was troublesome to do it at home along with broken and seized bolts as well as two  lambda sensors seized in as well  with very little access ,it can be done but not for the faint hearted  so for anybody attempting this project I wish you well 

regards to all

liam

Link to comment
Share on other sites


Hey Liam,

Well done on swapping them out yourself, I'd do the same if and when it comes to it, what did you pay for them in the end?

Just a tip you probably know anyway, make sure the car is fully warmed up before they test emissions, the difference between hot and warm / cold is literally pass and fail. I've been dragging a '96 MGF through successive MOT's, and they really struggle. I suggest anybody does not leave the car at the MOT station but book a while you wait appointment, give her a good thrash before you get there so she's cleared her pipes and then drive her straight in without shutting down.

My S-Type went though on 0.016% CO2 (0.2 pass) on the fast idle and 0.006% (0.3 pass) on the natural idle, with only 9ppm of HC where the pass is 200! Given she'd done c130K by her last test, I was super pleased and encouraged that I've got a good one and that it is one excellently designed and put together engine!

Cheers, Russ :yes:

Link to comment
Share on other sites

Hi Russ

I paid £198.00 including vat and came with two with the clamps and a tube of exhaust paste as well . I didn't use the clamps, if you want his phone number no problem he sends parts all over the country but he is local to where i live so I collected them

regards to all

liam

Link to comment
Share on other sites

  • 5 years later...
18 hours ago, wolfpeace87 said:

Please pass on the details to me as well as I'm urgently need to replace my catalytic converter. Thanks

Bought mine in recent months from the link below. They seem to know what they are selling, very helpful and quick delivery. Product good as well. Photos on my submissions in S-Type from a few months back.

https://www.onlineautomotive.co.uk/car-parts/Jaguar/S-Type/2.5L/Petrol/Premium/Exhausts/Catalytic-Converters/JAG1037H/1/34?gclid=EAIaIQobChMIpfeMq4eE9gIVP4BQBh1tZAOpEAQYASABEgJzqvD_BwE

 

Good luck and Best Wishes, Regards, John

 

Link to comment
Share on other sites


12 hours ago, Wrinkly said:

Bought mine in recent months from the link below. They seem to know what they are selling, very helpful and quick delivery. Product good as well. Photos on my submissions in S-Type from a few months back.

https://www.onlineautomotive.co.uk/car-parts/Jaguar/S-Type/2.5L/Petrol/Premium/Exhausts/Catalytic-Converters/JAG1037H/1/34?gclid=EAIaIQobChMIpfeMq4eE9gIVP4BQBh1tZAOpEAQYASABEgJzqvD_BwE

 

Good luck and Best Wishes, Regards, John

 

Hey John,

Thanks for the suggestion, I've ordered the cat and I'm going to install them on the weekend. Hopefully it all goes well. If you have any suggestions and ideas on how to go about with this any advice would be greatly appreciated. I found your posts about cats and I will give it a read.

Thanks again,

Elliott

Link to comment
Share on other sites

10 hours ago, wolfpeace87 said:

Hey John,

Thanks for the suggestion, I've ordered the cat and I'm going to install them on the weekend. Hopefully it all goes well. If you have any suggestions and ideas on how to go about with this any advice would be greatly appreciated. I found your posts about cats and I will give it a read.

Thanks again,

Elliott

Elliott, it is a reasonably straight forward job. The only pointers I could offer are what I imagine you will be well aware of anyway.: make certain you have the correct sized sockets etc., to avoid rounding off. Use a couple of soakings of WD40 and let it soak in before attempting to remove nuts, especially at the manifold. Be sure the joint at the manifold is seated correctly when you fit the new Converter and do not over torque the nuts.

Good Luck with the job. Best Wishes and Regards, John

Link to comment
Share on other sites

On 2/17/2022 at 9:28 AM, Wrinkly said:

Elliott, it is a reasonably straight forward job. The only pointers I could offer are what I imagine you will be well aware of anyway.: make certain you have the correct sized sockets etc., to avoid rounding off. Use a couple of soakings of WD40 and let it soak in before attempting to remove nuts, especially at the manifold. Be sure the joint at the manifold is seated correctly when you fit the new Converter and do not over torque the nuts.

Good Luck with the job. Best Wishes and Regards, John

Thanks, I got my cat out on first try, overnight soaking with WD40 Specialist Penetrate did the job, however they sent me a cat with the downstream sensor position on the pipe rather then on the cat it's self like the original cat. Will this mean I have to extend the wires of the O2 sensor? I have attached an image. Was your's the same?

 

 

IMG_2497.JPG

Link to comment
Share on other sites

41 minutes ago, wolfpeace87 said:

Thanks, I got my cat out on first try, overnight soaking with WD40 Specialist Penetrate did the job, however they sent me a cat with the downstream sensor position on the pipe rather then on the cat it's self like the original cat. Will this mean I have to extend the wires of the O2 sensor? I have attached an image. Was your's the same?

 

 

IMG_2497.JPG

No, mine was an exact replica/copy of the original equipment fitting.

Regards, John

Link to comment
Share on other sites

17 hours ago, Wrinkly said:

No, mine was an exact replica/copy of the original equipment fitting.

Regards, John

Yes, that's what I thought from your pictures. I had seen this model on eBay and was dreading receiving it. Unfortunately it turned up. I spoke to them and they are going to arrange a replacement. 

Thanks,

Elliott

Link to comment
Share on other sites

2 hours ago, wolfpeace87 said:

Yes, that's what I thought from your pictures. I had seen this model on ebay and was dreading receiving it. Unfortunately it turned up. I spoke to them and they are going to arrange a replacement. 

Thanks,

Elliott

Elliott, I know it is a nuisance getting the wrong specification delivered, but at least they have accepted their mistake and are arranging the correct replacement. Far better than you altering the wiring to the Lambda Sensors. Good luck when you eventually get to do the job.

 

Best Wishes and Regards, John

Link to comment
Share on other sites

On 2/19/2022 at 12:37 PM, Wrinkly said:

Elliott, I know it is a nuisance getting the wrong specification delivered, but at least they have accepted their mistake and are arranging the correct replacement. Far better than you altering the wiring to the Lambda Sensors. Good luck when you eventually get to do the job.

 

Best Wishes and Regards, John

Agreed, I definitely don't want to alter any wiring. 

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

Loading...
 Share




  • Join The Club

    Join the Jaguar Owners Club and be part of the Community. It's FREE!

  • Topics

  • Our picks

    • Simply Jaguar show at Beaulieu - Sunday 23rd June 2024
      Jaguar Owners Club have a stand at this year's Simply Jaguar event at the National Motor Museum at Beaulieu, Hampshire on Sunday 23rd June 2024

      Tickets are available online here: https://www.beaulieu.co.uk/events/simply-jaguar/
        • Like
      • 1 reply
    • JAGUAR’S LAST PETROL SPORTS CAR: F-TYPE ZP EDITION TAKES THE CHEQUERED FLAG
      Jaguar is commemorating the end of its internal combustion sports car lineage in 2024 with an exclusive limited-edition F-TYPE inspired by two iconic 1960s racing E-types

      Just 150 examples of the F-TYPE ZP Edition will be the last internal combustion-engined sports cars designed by Jaguar. These 575PS supercharged petrol V8 F-TYPEs feature specially curated interior and exterior details by the personalisation experts at SV Bespoke.
        • Like
    • UPDATE SHOW INFORMATION !

      Please find attached your club label – please can this be distributed amongst your club members prior to the event. Please ensure that they print this label and display it in their windscreen upon entry to the event, this ensures that all members wishing to park within your club area are directed to the correct parking location by our stewards. Please do not modify or add logos to the club label.

      We do ask that all individuals have purchased their tickets on an individual basis in advance via our website, to speed up the entry process on the day. This can be done on our website here until 2pm on the day when admission closes: https://www.beaulieu.co.uk/events/simply-jaguar.

      Note that we do have two entrances available, one is exhibitors gate at the bottom of the hill as you come in to Beaulieu, with the other being the normal Simply event entrance within the attraction. Either entrance is fine to use and both are open from 9.00am, with the exhibitors entrance closing around 11am.

      Jaguar Owners Club (1).pdf
    • Simply Jaguar - Beaulieu Motor Museum - 25th June 2023
      Jaguar Owners Club have a stand at this years Simply Jaguar event at the National Motor Museum at Beaulieu, Hampshire on Sunday 26th June 2023

      Tickets are available online here: https://www.beaulieu.co.uk/events/simply-jaguar/


      TICKETS & PRICES
      Participant prices are only valid if arriving in a Jaguar and taking part in the rally. They are not valid for those arriving on foot.

      Participants can make the most of our EARLY BIRD discount by booking before 28th February 2023.

      Children under 5 require a ticket, this can be booked online free of charge.

      Participant and visitor tickets will include entrance to the rest of the Beaulieu attraction, including the National Motor Museum, Palace House, Little Beaulieu, World of Top Gear, Beaulieu Abbey and its grounds and gardens.

      The best time for viewing the Simply rally is between 10am and 2pm.

       

       


      Adult


      Child




      Participants – Early Bird*


      £14.00


      £7.50




      Participants – Standard & On The Day


      £16.00


      £8.00




      Visitors


      Normal admission applies.


      Normal admission applies







      *Early bird tickets are available until 28th February 2023

      VEHICLE ENTRY
      Entry with your Jaguar is from 9am – 2pm. Please make sure you have your ticket printed or available on your phone, ready to be scanned on arrival.

      Please do not arrive early for our Simply rallies as no facilities will be open prior to 9:30am.

      Cars cannot leave and re-enter the grounds for the Simply rallies.

      ________________________________________________________________________________________________________________

      CLUB STAND ATTENDEE LIST

      We do ask for a final update on numbers 2 weeks prior to the event following which we will send out club labels to you via email for you to then distribute out to club members. Club members then need to print and display these in their windscreen on arrival. This helps us then park you all in your club area together.

      1. Trevor (admin)
      2.  Paj
      3.  
       
      • 5 replies
    • F-TYPE marks 75 years of Jaguar sports cars and its final model year update
      The Jaguar F-TYPE is the definitive Jaguar sports car from a rich bloodline spanning 75 years and including some of the most iconic models ever built
        • Like

×
×
  • Create New...



Forums


News


Membership