Jump to content


Gearbox Fault Warning


Blister
 Share

Recommended Posts

Hi,

I'm a brand new member with absolutely no mechanical knowledge so I hope another member can advise me.

I bought my car 6 weeks ago from a Jaguar main dealer. - A 2008 XType, 2.2 SE Diesel Automatic.

I drove my car locally and it was fine.

Last Friday I drove from Manchester to London using motorways all the way. As I left the M25 a dashboard warning came on. - A stable amber light with the words 'Gearbox Fault' and a flashing amber coil icon. I immediately found a safe place to park and switched off.

Two days later my breakdown service sent a mechanic to assess the car. This mechanic did a computer diagnostic check and told me 2 faults were reported. - There had been a problem with the turbo and then a knock on problem with the car accessing neutral. - The fault did not reoccur when the ignition was switched on again nor during a test drive. In effect the car was operating normally again.

The mechanic concluded that if a fault still existed it was intermittent. Other than that, from experience, he could confirm my gearbox was not faulty and that the fault was turbo related. - He said turbo problems caused the 'Gearbox Fault' warning to display even though the gearbox was not faulty and the car was safe to drive.

I later drove the car back to Manchester without mishap but I am still concerned that I may have an underlying problem.

Has anyone else had a similar experience?

Did the mechanic tell me the truth?

My car is still under warranty and will be going back to the seller for another check but I would like to be able to ensure they do not 'blind me with science' to evade responsibility for an expensive repair.

Thanks guys.

Link to comment
Share on other sites

Hi John, and welcome to the club.

 

I am no engineer either, and I would do exactly what you are doing if the car is still under warranty.

 

A main dealer should have a very good diagnostic system and if you mention when they have checked it, and if they and it OK, that the breakdown mechanic pointed towards the turbo.

 

Good Luck

 

Peter.

Link to comment
Share on other sites

Thanks Peter.

 

I really want to know if there is anything I need to be aware of so I can ensure my car is 100% after the dealers warranty check.- I'm naturally cynical and suspicious and I don't want to be 'fobbed off' then later down the line find my warranty has expired and I have an unexpected and expensive bill to pay for repairs.

 

John

Link to comment
Share on other sites

Hi

 

I have a 2008 X type manual and my clutch went @ 22,000 miles which I was obviously not happy about. I complained to Jaguar and they footed the £1500 bill. After it was fitted Jaguar gave me a courtesy call and to check I was happy and also advised me that they have had issues with the clutches fitted!!!

Link to comment
Share on other sites

Hi Guys

 

Thanks Tracharr.

 

A quick update. - My car went for assessment by the supplying main dealer 2 days ago. They could not make it replicate the fault so presume it is intermittent. I've just had a phone call to say they have had discussions with the warrant company. In view of the circs. the warranty company will authorise and pay for a new turbo / actuator to be supplied and fitted. - No idea what that may be but as long as it cures the problem I don't care. - Car goes back to the shop next week.

 

John

Link to comment
Share on other sites


Hi John,

I have an x Type diesel auto 08 reg and had exactly the same problem except it went into limp mode. I took it to a independent Jag specialist with all the right software and they diagnosed turbo problem. Fitted new turbo last week and it is fine. As you say the message comes up as gearbox fault Otherwise this is the first Jag I have owned and really love it to drive and looking forward to coupling up my caravan to see if it tows as well as my previous car, Rover 75 diesel auto.

Cheers

Rod

Link to comment
Share on other sites


  • 1 year later...

I've had a very similar problem - x type diesel, 2008, 2.2 auto, 130k miles, going into limp mode with amber light and gearbox fault on the display. I've had diagnostics done by a Jaguar independent dealer (who were convinced in advance that it would be the turbo) but nothing comes up and I've since driven the car with absolutely no problems at all. But it does knock one's confidence a bit... If anyone has any further thoughts or experience on this please do let me know - I've had another thread going on this on the forum too along similar lines. In the meantime I've got a simple diagnostic tool in the glovebox so I can try and get some clue as to what the problem might be if/when it happens again.

Cheers

Liam

Link to comment
Share on other sites

Hi Liam, Yes I had exactly the same problem and finished up replacing the turbo. The warranty outfit refused to pay out as they said there was signs of carbon in the turbo. After some words with the garage that I bought the car from, as I had only had the car for a few weeks. The garage were very good and paid for the new turbo. This was all 20,000 miles ago and not had any problem since. My car has now done 112,000 miles and I love it.

Cheers

Rod

Link to comment
Share on other sites

  • 2 years later...

I have s type have automatic diesel 2005 done 97000 miles. I had same warning twice recently when it was raining. First time I thought the gearbox was stuck in 3rd gear as revs going up to 4000 if I put my foot down. Since no problems. Should I get it checked out?

Link to comment
Share on other sites

  • 1 month later...
On 10/15/2015 at 3:01 PM, Blister said:

Hi,

I'm a brand new member with absolutely no mechanical knowledge so I hope another member can advise me.

I bought my car 6 weeks ago from a Jaguar main dealer. - A 2008 XType, 2.2 SE Diesel Automatic.

I drove my car locally and it was fine.

Last Friday I drove from Manchester to London using motorways all the way. As I left the M25 a dashboard warning came on. - A stable amber light with the words 'Gearbox Fault' and a flashing amber coil icon. I immediately found a safe place to park and switched off.

Two days later my breakdown service sent a mechanic to assess the car. This mechanic did a computer diagnostic check and told me 2 faults were reported. - There had been a problem with the turbo and then a knock on problem with the car accessing neutral. - The fault did not reoccur when the ignition was switched on again nor during a test drive. In effect the car was operating normally again.

The mechanic concluded that if a fault still existed it was intermittent. Other than that, from experience, he could confirm my gearbox was not faulty and that the fault was turbo related. - He said turbo problems caused the 'Gearbox Fault' warning to display even though the gearbox was not faulty and the car was safe to drive.

I later drove the car back to Manchester without mishap but I am still concerned that I may have an underlying problem.

Has anyone else had a similar experience?

Did the mechanic tell me the truth?

My car is still under warranty and will be going back to the seller for another check but I would like to be able to ensure they do not 'blind me with science' to evade responsibility for an expensive repair.

Thanks guys.

I have had the same problem and cured it by replacing EGR valve 

Link to comment
Share on other sites


Hi Anthony, I have the same car and had exactly the same problem soon after I bought the car. Took it back to seller and they cleaned the EGR valve but it did it again a few days later so I took it to Independent Jag garage in Hull and they diagnosed turbo actuator fault. Replaced and car has been fine since and seller paid for repair as I tried to claim via my Warranty Wise but they refused to cover the cost. this was over 50k ago and it drives lovely. This is a great car to drive. Enjoy it.

Cheers

Rod

Link to comment
Share on other sites

Hi Anthony. 
 

sorry not to reply to your post sooner. I too have had the exact same problem - it happened about 6 times in a few months a few years back, like you fairly shortly after purchase. if you search in my profile or under gearbox or similar in the x-type forum you should find mine and quite a few other threads on the subject. 
 

I like you have no mechanical knowledge at all so appreciate how dismaying and worrying these events are, but my own experience is that it is not as bad as it seems. Most diagnoses seem to point to an issue with either the EGR or turbo - but in my case a check from the garage revealed no problem with either of these items - they did actually replace the EGR in the end but said they could find absolutely nothing wrong with the old one but they had a new one and thought they might as well give it a go. I didn’t replace the turbo as that was pretty expensive and again the garage could not find any reason to go down that road.

Bizarrely what cleared it up for me was actually just a service and Oil change. I had it done on schedule and since then have never had the problem again. I commented on this to the garage and they said it was probably some glitch on the feedback from the turbo or exhaust etc and an additive they had at service might have cleared something. so a bit of diesel injector fluid might well solve your problems too.
 

my advice is also to find a decent independent jag specialist who will recognise all these little quirks with the x type and know the back routes and anecdotal solutions which do often work and save you a packet in the meantime. Or just a good mechanic whom you trust.

if you’re still having problems try a bit of fuel additive like wynns and see if that helps. Or just a routine service before any other costly interventions.

as I say I’m not a mechanic and only speaking purely from my own experience which I hope may be helpful - obviously you may turn out to have a more serious problem but hopefully not. My car was purchased at 108000 miles and not just coming up to 167000 and still going strong.

good luck  

Nathan 

Link to comment
Share on other sites

hi had the same problem with my 08 plate x type the variable vain on the turbo gets clogged up and can be cleaned with oven cleaner(see on youtube) but you can get you can get home by dissconnecting the actuature rod to turbo ,this stops the gearbox going into limp mode.

regards

david

Link to comment
Share on other sites

  • 10 months later...

Hi, I have the same problem with a 2008 X Type I have just purchased. I have the flashing glow plugs indicator and gearbox problem message. Reading this thread I can see that the turbo actuator either needs to be replaced or rebuilt. I rang my local independent Jag servicing and they said that the whole turbo needed to be replaced c. £2K. This is more than I paid for the car so I wanted to know what people thought about what needed to be done and what they would expect the cost would be? Many thanks, Fraser 

Link to comment
Share on other sites

Hi Fraser, I have the same model and did have the same problem of showing the gearbox fault and going into limp mode. I only had the car for a couple of weeks so took it back to garage where I bought it from and they tried all sorts of cures including replacing EGR valve. It was ok for a few days but then started with the problem again. After agreeing with the garage that they would be paying for repairs I took it to Jagutech in Hull and they replaced the turbo actuator, although they did say that there was quite a lot of carbon in the turbo vanes. I dont know how much everything cost as the garage I bought it from paid for it. It has been ok since and that was 50k ago !! I`m fairly sure that you can get a recon turbo for about £500 but dont know how easy it is to swap them over. Hope this helps.

Cheers

Rod

  • Like 1
Link to comment
Share on other sites

  • 8 months later...

Hi people, I had the gearbox fault come on on my 2.2tdi and went into limp mode. At the same time the " DPF FULL" sign came up. Kept the car going, on an empty road and did 8 miles at 3000 rpm. The DPF warning went out, so I stopped and turned the engine off waited 10 minutes and restarted,bingo!

I've had similar problems with a different car with a DPF , so just thought I'd give it a go and it worked! I would recommend you try this if you have the time and patience( and an empty road!  My car is 09 plate six speed box 145000 miles.

Link to comment
Share on other sites

  • 2 years later...

I have gearbox fault come on but they can't find any thing at all on the computer been driving round town recently  for about 4 to5 week today took it out to Hexham about 17 miles there and 17 miles back drove ok put my foot down where I could up to 70mph seem OK but I bet tomorrow it will play up again can any one help.

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

Loading...
 Share





  • Join The Club

    Join the Jaguar Owners Club and be part of the Community. It's FREE!

     

  • Topics

  • Our picks

    • Simply Jaguar show at Beaulieu - Sunday 23rd June 2024
      Jaguar Owners Club have a stand at this year's Simply Jaguar event at the National Motor Museum at Beaulieu, Hampshire on Sunday 23rd June 2024

      Tickets are available online here: https://www.beaulieu.co.uk/events/simply-jaguar/
        • Like
      • 1 reply
    • JAGUAR’S LAST PETROL SPORTS CAR: F-TYPE ZP EDITION TAKES THE CHEQUERED FLAG
      Jaguar is commemorating the end of its internal combustion sports car lineage in 2024 with an exclusive limited-edition F-TYPE inspired by two iconic 1960s racing E-types

      Just 150 examples of the F-TYPE ZP Edition will be the last internal combustion-engined sports cars designed by Jaguar. These 575PS supercharged petrol V8 F-TYPEs feature specially curated interior and exterior details by the personalisation experts at SV Bespoke.
        • Like
    • UPDATE SHOW INFORMATION !

      Please find attached your club label – please can this be distributed amongst your club members prior to the event. Please ensure that they print this label and display it in their windscreen upon entry to the event, this ensures that all members wishing to park within your club area are directed to the correct parking location by our stewards. Please do not modify or add logos to the club label.

      We do ask that all individuals have purchased their tickets on an individual basis in advance via our website, to speed up the entry process on the day. This can be done on our website here until 2pm on the day when admission closes: https://www.beaulieu.co.uk/events/simply-jaguar.

      Note that we do have two entrances available, one is exhibitors gate at the bottom of the hill as you come in to Beaulieu, with the other being the normal Simply event entrance within the attraction. Either entrance is fine to use and both are open from 9.00am, with the exhibitors entrance closing around 11am.

      Jaguar Owners Club (1).pdf
    • Simply Jaguar - Beaulieu Motor Museum - 25th June 2023
      Jaguar Owners Club have a stand at this years Simply Jaguar event at the National Motor Museum at Beaulieu, Hampshire on Sunday 26th June 2023

      Tickets are available online here: https://www.beaulieu.co.uk/events/simply-jaguar/


      TICKETS & PRICES
      Participant prices are only valid if arriving in a Jaguar and taking part in the rally. They are not valid for those arriving on foot.

      Participants can make the most of our EARLY BIRD discount by booking before 28th February 2023.

      Children under 5 require a ticket, this can be booked online free of charge.

      Participant and visitor tickets will include entrance to the rest of the Beaulieu attraction, including the National Motor Museum, Palace House, Little Beaulieu, World of Top Gear, Beaulieu Abbey and its grounds and gardens.

      The best time for viewing the Simply rally is between 10am and 2pm.

       

       


      Adult


      Child




      Participants – Early Bird*


      £14.00


      £7.50




      Participants – Standard & On The Day


      £16.00


      £8.00




      Visitors


      Normal admission applies.


      Normal admission applies







      *Early bird tickets are available until 28th February 2023

      VEHICLE ENTRY
      Entry with your Jaguar is from 9am – 2pm. Please make sure you have your ticket printed or available on your phone, ready to be scanned on arrival.

      Please do not arrive early for our Simply rallies as no facilities will be open prior to 9:30am.

      Cars cannot leave and re-enter the grounds for the Simply rallies.

      ________________________________________________________________________________________________________________

      CLUB STAND ATTENDEE LIST

      We do ask for a final update on numbers 2 weeks prior to the event following which we will send out club labels to you via email for you to then distribute out to club members. Club members then need to print and display these in their windscreen on arrival. This helps us then park you all in your club area together.

      1. Trevor (admin)
      2.  Paj
      3.  
       
        • Like
      • 5 replies
    • F-TYPE marks 75 years of Jaguar sports cars and its final model year update
      The Jaguar F-TYPE is the definitive Jaguar sports car from a rich bloodline spanning 75 years and including some of the most iconic models ever built
        • Like

×
×
  • Create New...



Forums


News


Membership